Product ID:PETROLEUM-BASED LUBRICATING OIL
MSDS Date:03/20/1998
FSC:2805
NIIN:01-337-1179
Status Code:A
Kit Part:Y
MSDS Number: CLDXN

Emergency Phone: 800-274-5263

Info Phone: 606-357-7206 / 800-274-5263

Cage: 72527

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

PETROLEUM LUBE OIL

CAS: 64742-65-0

RTECS: PY8038500

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

DETERGENT / DISPERSANT ENGINE OIL PACKAGE

VISCOSITY INDEX IMPROVER

ZINC COMPOUNDS

Health Hazards Acute and Chronic:EYES: MAY CAUSE MILD IRRITATION. SKIN:
MAY CAUSE MILD IRRITATION. PROLONGED OR REPEATED EXPOSURE MAY DRY
SKIN. INGESTION: SINGLE DOSE ORAL TOXICITY IS LOW. SWALLOWING
SMALL AMOUNTS DURING NORMAL HAND LING IS NOT LIKELY TO CAUSE
HARMFUL EFFECTS; SWALLOWING LARGE AMOUNTS MAY BE HARMFUL.
INHALATION: EXPOSURE IS POSSIBLE UNDER CERTAIN CONDITIONS OF
HANDLING AND USE (FOR EXAMPLE, DURING HEATING, SPRAY ING, OR
STIRRING). SYMPTOMS ARE MORE TYPICALLY SEEN AT AIR CONCENTRATIONS
EXCEEDING THE RECOMMENDED EXPOSURE LIMITS.
Explanation of Carcinogenicity:USED MOTOR OIL HAS BEEN SHOWN TO CAUSE
SKIN CANCER IN LABORATORY ANIMALS CONTINUALLY EXPOSED BY REPEATED
APPLICATIONS. AVOID PROLONGED OR REPEATED SKIN CONTACT.
Effects of Overexposure:EYES: STINGING, TEARING, AND REDNESS. SKIN:
REDNESS, BURNING, DRYING, CRACKING, AND SKIN BURNS. INGESTION:
SMALL AMOUNTSNOT LIKELY TO CAUSE HARMFUL EFFECTS; LARGE AMOUNTS MAY
BE HARMFUL. INHALATION: G ASTROINTESTINAL IRRITATION, NAUSEA,
VOMITING, DIARRHEA, IRRITATION OF NOSE, THROAT, RESPIRATORY TRACTB
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS MATERIAL. PRE-EXISTING LUNG
DISORDERS, ASTHMA-LIKE CONDITIONS, MAY BE AGGRAVATED BY EXPOSURE TO
THIS MATERIAL, ABDOMINAL PAIN.

First Aid:EYES: MOVE TO FRESH AIR. FLUSH WITH WATER WHILE HOLDING
EYELIDS APART. IF SYMPTOMS PERSIST, GET MEDICAL ATTENTION. SKIN:
REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. WASH EXPOSED
AREA WITH S OAP AND WATER. IF SYMPTOMS PERSIST, GET MEDICAL
ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GIVE ONE GLASS OF
MILK OR WATER, AND GET MEDICAL ATTENTION. IF POSSIBLE, DO NOT LEAVE
VICTIM UNATTENDED. I NHALATION: MOVE TO FRESH AIR. GET MEDICAL
ATTENTION. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING DIFFICULT, GIVE OXYGEN.

Flash Point Method:COC
Flash Point:>198.9C, 390.F
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE, DRY CHEMICAL. WATER
OR FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT AND POSSIBLY
ENDANGER THE LIFE OF THE FIREFIGHTER.
Fire Fighting Procedures:WEAR A SELF-CONTAINED BREATHING APPARATUS WITH
A FULL FACEPIECE OPERATED IN THE POSITIVE PRESSURE DEMAND MODE
WITH APPROPRIATE TURN-OUT GEAR AND CHEMICAL RESISTANT PERSONAL
PROTECTIVE EQUIPMENT. REFE R TO PERSONAL PROTECTIVE EQUIPMENT
SECTION OF THIS MSDS.
Unusual Fire/Explosion Hazard:HAZARDOUS PRODUCTS OF COMBUSTION: MAY
FORM CARBON DIOXIDE, CARBON MONOXIDE, OXIDES OF SULFUR, NITRIGEN
AND PHOSPHORUS, VARIOUS HYDROCARBONS. NEVER USE WELDING OR CUTTING
TORCH ON OR NEAR (EVEN EMPTY) BECAUSE PRODUCT(EVEN JUST RESIDUE)
CAN IGNITE EXPLOSIVELY. DENSE SMOKE MAY BE GENERATED WHILE BURNING.

Spill Release Procedures:ABSORB SMALL SPILL ON VERMICULITE, FLOOR
ABSORBENT OR OTHER ABSORBENT. LARGE SPILL: PREVENT RUN-OFF TO
SEWERS, STREAMS, OTHER BODIES OF WATER. IF RUN-OFF OCCURS, NOTIFY
AUTHORITIES AS REQUIRED. STOP S PILL AT SOURCE, DIKE AREA TO
PREVENT SPREADING, PUMP LIQUID TO SALVAGE TANK. REMAINING LIQUID
MAY BE TAKEN UP ON SAND, CLAY, EARTH, FLOOR OR OTHER ABSORBENT
MATERIAL AND SHOVELED INTO CONTAINERS.

Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED. SICE EMPTIED CONTAINERS RETAIN PRODUCT
RESIDUES (VAPOR, LIQID, AND/ OR SOLID), ALL HAZARD PRECAUTIONS
GIVEN IN THE DATA SHEET MUST BE OBSERVE D.

Respiratory Protection:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
HOWEVER, IF OIL MISTS ARE GENERATED ABOVE RECOMMENDED PEL/TLV OF 5
MG/M3, THEN A NIOSH/MSHA APPROVED RESPIRATOR IS ADVISED IN ABSENCE
OF PROPER ENVIRONMENT AL CONTROL. (CONSULT YOUR INDUSTRIAL
HYGIENIST.)
Ventilation:NOT REQUIRED UNDER NORMAL CONDITIONS OF USE. IF NEEDED,
PROVIDE SUFFICIENT MECHANICAL (GENERAL) OR LOCAL EXHAUST
VENTILATION TO MAINTAIN EXPOSURE BELOW PEL/TLV
Protective Gloves:NOT NORMALLY REQUIRED. RESISTANT GLOVES TO PREVENT
IRRITATION FROM CONTACT.
Eye Protection:NOT REQUIRED FOR NORMAL CONDITIONS. SAFETY GLASSES /
SPLASH GOGGLES I F MISTING
Other Protective Equipment:NOT NORMALLY REQUIRED. HOWEVER, WEAR
RESISTANT GLOVES SUCH AS NITRIL RUBBER TO PREVENT IRRITATION FROM
PROLONGED OR REPEATED SKIN CONTACT. WEAR NORMAL WORK CLOTHING
COVERING ARMS AND LEGS.
Supplemental Safety and Health
THIS ENTRY DESCRIBES PART 4 ( LUBRICATING OIL, SERIAL NUMBER XXXXX) OF
A FOUR PART KIT. SEE THIS SAME NSN FOR P/N 525-0614 PAINT SPRAY,
SERIAL NUMBER CLDWF; AND LEAD ACID BATTERY, SERIAL NUMBER CLDXG ;
AND FOR SERIAL NUMBER CLDVW, GASOLINE ENGINE FOR DATA ON OTHER
THREE KIT PARTS.

HCC:V6
Boiling Pt:>425.C, 797.F
Spec Gravity:0.880 @ 60F (7.37 LBS/GL)
Viscosity:< 3300 CPS
Evaporation Rate & Reference:SLOWER THAN ETHER.
Appearance and Odor:AMBER COLOR LIQUID WITH PETROLEUM ODOR.

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:MAY FORM: CARBON DIOXIDE AND CARBON
MONOXIDE, OXIDES OF SULFUR, NITROGEN AND PHOSPHORUS, VARIOUS
HYDROCARBONS.
Conditions to Avoid Polymerization:PRODUCT WILL NOT UNDERGO HAZARDOUS
POLYMERIZATION.

Waste Disposal Methods:DISPOSE OF IN ACORDANCE WITH ALL APPLICABLE
LOCAL, STATE, AND FEDERAL REGULATIONS.

Toxicological Information:NO DATA

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NO DATA.

Transport Information:DOT INFORMATION - 49CFR 172.101: DOT DESCRIPTION:
NOT REGULATED. CONTAINER / MODE: CASES / SURFACE - NO EXEMPTIONS.
N.O.S. COMPONT: NONE. RQ (REPORTABLE QUANTITY) 49 CFR 172.101: NOT
APPLICABLE.

SARA Title III Information:SARA 302 COMPONENTS - 40 CFR 355 APPENDIX A:
NONE. SECTION 311 / 312 HAZARD CLASS - 40 CFR.2: IMMEDIATE;
DELAYED. SARA 313 COMPONENTS - 40 CFR 372.65: SECTION 313
COMPONENTS: ZUNC COMPOUNDS; 1.38 MAX. %.
Federal Regulatory Information:TSCA (TOXIC SUBSTANCES CONTROL ACT)
STATUS: TSCA (UNITED STATES) THE INTENTIONAL INGREDIENTS OF THIS
PRODUCT ARE LISTED. CERCLA RQ - 40 CFR 302.4: NONE.
State Regulatory Information:CALIFORNIA PROPOSITION 65: NONE.